2000 Volvo S40

Central Front Lower Power steering pipe/hose has slight seepage (2.1.5 (a))

Nearside Front Outer Suspension arm ball joint has slight play (5.3.4 (a) (i))

Nearside Front Outer Suspension arm ball joint has slight play (5.3.4 (a) (i))

Offside Front Outer Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Front Shock absorbers has light misting of oil (5.3.2 (b))

Offside Rear Outer Integral body structure is deformed but structural rigidity is not significantly reduced Rear quarter panel deformed (6.1.1 (a) (i))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Offside Front Lower Oil leaking excessively from engine (8.4.1 (a) (i))

Offside Front Seat belt webbing significantly weakened cut from edge greater than 2mm (7.1.2 (b))

Central Front Lower Power steering pipe/hose has slight seepage (2.1.5 (a))

Nearside Front Outer Suspension arm ball joint has slight play (5.3.4 (a) (i))

Nearside Front Outer Suspension arm ball joint has slight play (5.3.4 (a) (i))

Offside Front Outer Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Front Shock absorbers has light misting of oil (5.3.2 (b))

Offside Rear Outer Integral body structure is deformed but structural rigidity is not significantly reduced Rear quarter panel deformed (6.1.1 (a) (i))

Offside Rear Service brake binding but not excessively (1.2.1 (f))

Offside Rear Suspension component mounting repair covered in underseal inner sill (5.3.6 (a) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Brake fluid contaminated (1.8 (a))

Brake performance unable to be tested (1.2.1 (g))

Nearside Front Brake disc significantly and obviously worn (1.1.14 (a) (i))

Nearside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Nearside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i))

Offside Front Anti-roll bar ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Brake disc significantly and obviously worn (1.1.14 (a) (i))

Offside Front Direction indicator incorrect colour (4.4.3 (a))

Offside Front Lower Suspension arm ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Front Shock absorbers has a serious fluid leak (5.3.2 (b))

Offside Rear Brake disc significantly and obviously worn (1.1.14 (a) (i))

Nearside Rear Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Oil leak, but not excessive (8.4.1 (a) (i))

general underside corrosion

Offside Front Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

brake pedal spongy

engine bay and under body covers fitted obscuring testable items from view

Nearside Headlamp aim too high (4.1.2 (a))

Offside Headlamp aim unable to be tested (4.1.2 (b))

Offside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Nearside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

brake pedal spongy

engine bay and under body covers fitted obscuring testable items from view

Nearside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

engine bay and under body covers fitted obscuring testable items from view

Central Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Coil spring corroded All (5.3.1 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Suspension arm ball joint dust cover severely deteriorated Both (5.3.4 (b) (i))

Fuel Pipe/s corroded ()

Headlamp reflector slightly defective Both (4.1.1 (b) (i))

Offside Front Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear All position lamps with a multiple light source up to 1/2 not functioning (4.2.1 (a) (i))

Rear Brake pipe corroded, covered in grease or other material All (1.1.11 (c))

Rear Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Rear Suspension component pin or bush slightly worn All tie bars (5.3.4 (a) (i))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Central Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Coil spring corroded All (5.3.1 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Suspension arm ball joint dust cover severely deteriorated Both (5.3.4 (b) (i))

Fuel Pipe/s corroded ()

Headlamp reflector slightly defective Both (4.1.1 (b) (i))

Offside Front Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Direction indicator incorrect colour (4.4.3 (a))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear All position lamps with a multiple light source up to 1/2 not functioning (4.2.1 (a) (i))

Rear Brake pipe corroded, covered in grease or other material All (1.1.11 (c))

Rear Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Rear Suspension component pin or bush slightly worn All tie bars (5.3.4 (a) (i))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Central Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Coil spring corroded all (5.3.1 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Suspension arm ball joint dust cover severely deteriorated both (5.3.4 (b) (i))

Fuel Pipe/s corroded ()

Headlamp reflector slightly defective both (4.1.1 (b) (i))

Offside Front Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Rear Brake pipe corroded, covered in grease or other material all (1.1.11 (c))

Rear Integral body structure is corroded but structural rigidity is not significantly reduced (6.1.1 (c) (i))

Rear Position lamp with a multiple light source up to 1/2 not functioning both (4.2.1 (a) (i))

Rear Suspension component pin or bush slightly worn all tie bars (5.3.4 (a) (i))

Rear Tyre worn close to legal limit/worn on edge both (5.2.3 (e))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

rear tyres distorted

rear tyres distorted

Coil spring corroded all (5.3.1 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Integral body structure is corroded but structural rigidity is not significantly reduced crossmember (6.1.1 (c) (i))

Front Suspension arm ball joint dust cover severely deteriorated both (5.3.4 (b) (i))

Fuel Pipe/s corroded ()

Headlamp reflector slightly defective both (4.1.1 (b) (i))

Offside Front Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Direction indicator slightly discoloured (4.4.3 (a))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Anti-roll bar linkage ball joint dust cover severely deteriorated both (5.3.4 (b) (i))

Rear Brake pipe corroded, covered in grease or other material all (1.1.11 (c))

Rear Position lamp with a multiple light source up to 1/2 not functioning both (4.2.1 (a) (i))

Rear Suspension component pin or bush slightly worn all (5.3.4 (a) (i))

Rear Tyre worn close to legal limit/worn on edge both inner edge (5.2.3 (e))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Towbar slightly corroded within 30cm of towbar mounting (6.1.6 (i) (i))

rear exhaust flange corroded

Front Position lamp not working both (4.2.1 (a) (ii))

Nearside Front Anti-roll bar linkage ball joint dust cover no longer prevents the ingress of dirt (5.3.4 (b) (ii))

Offside Track rod end ball joint dust cover excessively damaged or deteriorated so that it no longer prevents the ingress of dirt (2.1.3 (g) (ii))

Registration plate lamp inoperative in the case of a single lamp or all lamps both (4.7.1 (b) (ii))

Windscreen washer provides insufficient washer liquid (3.5 (a))

Coil spring corroded all (5.3.1 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Integral body structure is corroded but structural rigidity is not significantly reduced crossmember (6.1.1 (c) (i))

Front Suspension arm ball joint dust cover severely deteriorated both (5.3.4 (b) (i))

Fuel Pipe/s corroded ()

Headlamp reflector slightly defective both (4.1.1 (b) (i))

Offside Front Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Offside Front Direction indicator slightly discoloured (4.4.3 (a))

Oil leak, but not excessive (8.4.1 (a) (i))

Rear Anti-roll bar linkage ball joint dust cover severely deteriorated both (5.3.4 (b) (i))

Rear Brake pipe corroded, covered in grease or other material all (1.1.11 (c))

Rear Position lamp with a multiple light source up to 1/2 not functioning both (4.2.1 (a) (i))

Rear Suspension component pin or bush slightly worn all (5.3.4 (a) (i))

Rear Tyre worn close to legal limit/worn on edge both inner edge (5.2.3 (e))

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Towbar slightly corroded within 30cm of towbar mounting (6.1.6 (i) (i))

rear exhaust flange corroded

rear tyres distorted

Coil spring corroded all (5.3.1 (b) (i))

Front Anti-roll bar linkage ball joint dust cover severely deteriorated both (5.3.4 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Suspension arm ball joint dust cover severely deteriorated both (5.3.4 (b) (i))

Fuel Pipe/s corroded ()

Headlamp reflector slightly defective both (4.1.1 (b) (i))

Nearside Front Tyre has a cut but not deep enough to reach the ply or cords (5.2.3 (d) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Rear Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Suspension component pin or bush slightly worn all rear tie bars (5.3.4 (a) (i))

Towbar slightly corroded within 30cm of towbar mounting (6.1.6 (i) (i))

exhaust corroded

Offside Rear Seat belt anchorage prescribed area strength or continuity significantly reduced outer sill (7.1.1 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i))

Offside Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Coil spring corroded all (5.3.1 (b) (i))

Front Anti-roll bar linkage ball joint dust cover severely deteriorated both (5.3.4 (b) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Suspension arm ball joint dust cover severely deteriorated both (5.3.4 (b) (i))

Fuel Pipe/s corroded ()

Headlamp reflector slightly defective both (4.1.1 (b) (i))

Nearside Front Tyre has a cut but not deep enough to reach the ply or cords (5.2.3 (d) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Track rod end ball joint dust cover damaged or deteriorated, but preventing the ingress of dirt (2.1.3 (g) (i))

Rear Anti-roll bar linkage ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Suspension component pin or bush slightly worn all rear tie bars (5.3.4 (a) (i))

Towbar slightly corroded within 30cm of towbar mounting (6.1.6 (i) (i))

exhaust corroded

Front Lower Suspension arm ball joint dust cover deteriorated, but preventing the ingress of dirt both (2.4.G.2)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Front coil spring corroded both (2.4.C.1b)

Fuel Pipe/s corroded ()

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Track rod end ball joint dust cover deteriorated, but preventing the ingress of dirt (2.2.C.1c)

Parking brake lever has little reserve travel (3.1.6b)

Rear Tie bar/rod rubber bush deteriorated but not resulting in excessive movement all (2.4.G.2)

both rear tyres slightly distorted

exhaust corroded

Front Lower Suspension arm ball joint dust cover deteriorated, but preventing the ingress of dirt both (2.4.G.2)

Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Front coil spring corroded both (2.4.C.1b)

Fuel Pipe/s corroded ()

Nearside Headlamp aim too low (1.8)

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Registration plate lamp not working (1.1.C.1d)

Offside Track rod end ball joint dust cover deteriorated, but preventing the ingress of dirt (2.2.C.1c)

Parking brake lever has little reserve travel (3.1.6b)

Rear Tie bar/rod rubber bush deteriorated but not resulting in excessive movement all (2.4.G.2)

both rear tyres slightly distorted

exhaust corroded

Front Lower Suspension arm ball joint dust cover damaged, but preventing the ingress of dirt both (2.4.G.2)

Fuel Pipe/s corroded ()

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Front Direction indicator damaged, but still visible from a reasonable distance (1.4.A.2e)

Oil leak ()

Parking brake lever has little reserve travel (3.1.6b)

Play in steering rack inner joint(s) ()

Rear Brake pipe slightly corroded (3.6.B.2c)

Rear Suspension arm rubber bush deteriorated but not resulting in excessive movement both (2.4.G.2)

Rear Tie bar/rod rubber bush deteriorated but not resulting in excessive movement all (2.4.G.2)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

coil spring corroded all (2.4.C.1b)

exhaust corroded

Nearside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Nearside Track rod end ball joint has excessive play (2.2.B.1f)

Offside Headlamp aim beam image obviously incorrect (1.8.A.1b)

Offside Registration plate lamp not working (1.1.C.1d)

Parking brake: efficiency below requirements (3.7.B.7)

Rear Brakes imbalanced across an axle Axle 2 (3.7.B.5b)

Windscreen washer provides insufficient washer liquid (8.2.3)

Front Lower Suspension arm ball joint dust cover damaged, but preventing the ingress of dirt both (2.4.G.2)

Fuel Pipe/s corroded ()

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Front Direction indicator damaged, but still visible from a reasonable distance (1.4.A.2e)

Oil leak ()

Parking brake lever has little reserve travel (3.1.6b)

Play in steering rack inner joint(s) ()

Rear Brake pipe slightly corroded (3.6.B.2c)

Rear Suspension arm rubber bush deteriorated but not resulting in excessive movement both (2.4.G.2)

Rear Tie bar/rod rubber bush deteriorated but not resulting in excessive movement all (2.4.G.2)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

coil spring corroded all (2.4.C.1b)

exhaust corroded

Exhaust has a minor leak of exhaust gases (7.1.2)

Front Brake pipe slightly corroded (3.6.B.2c)

Front Lower Suspension arm ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Rear coil spring corroded (2.4.C.1b)

Exhaust has a minor leak of exhaust gases (7.1.2)

Front Brake pipe slightly corroded (3.6.B.2c)

Front Lower Suspension arm ball joint dust cover deteriorated, but preventing the ingress of dirt (2.4.G.2)

Nearside Headlamp deteriorated but light output not reduced (1.7.5a)

Offside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Rear coil spring corroded (2.4.C.1b)

Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Fuel pipe/s corroded

Rear Brake pipe slightly corroded (3.6.B.2c)

n/s/r tyre distorted

Rear Tie bar/rod rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

rear tyres starting to perish

Centre Exhaust system not adequately supported (7.1.1)

Centre Rear Exhaust system not adequately supported (7.1.1)

Nearside Front Brake hose excessively deteriorated (3.6.B.4d)

Offside Front Brake hose excessively deteriorated (3.6.B.4d)

Rear Tie bar/rod rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

rear tyres starting to perish

Exhaust has part of the system slightly deteriorated (7.1.1a)

both outer sills not fully checked due to sill trims

Exhaust has part of the system slightly deteriorated (7.1.1a)

both rear tyres slightly out of shape and getting low

wear to all brake discs

Child seat fitted not allowing full inspection of adult belt