2004 Volvo XC90

Front Inner Suspension arm pin or bush worn but not resulting in excessive movement Both, Deteriorated (5.3.4 (a) (i))

General Corrosion Underside of Vehicle & suspension Components

Headlamp lens slightly defective Both (4.1.1 (b) (i))

Nearside Front Inner Road wheel slightly distorted Considerable (5.2.2 (c) (i))

Offside Front Inner Play in steering rack inner joint(s) Considerable ()

Offside Rear Combination Lamp Lens Damaged

Rear Brake disc worn, pitted or scored, but not seriously weakened Both, Corroding (1.1.14 (a) (ii))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Rear Subframe mounting prescribed area is corroded but not considered excessive Both (5.3.6 (a) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement All, Deteriorating (5.3.4 (a) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Both, Forward, Separating, Considerable! (5.3.4 (a) (i))

Side repeater slightly discoloured Both (4.4.3 (a))

Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Nearside Front Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Front Inner Suspension arm pin or bush worn but not resulting in excessive movement Both, Deteriorated (5.3.4 (a) (i))

General Corrosion Underside of Vehicle & suspension Components

Headlamp lens slightly defective Both (4.1.1 (b) (i))

Nearside Front Inner Road wheel slightly distorted Considerable (5.2.2 (c) (i))

Offside Front Inner Play in steering rack inner joint(s) Considerable ()

Offside Rear Combination Lamp Lens Damaged

Rear Brake disc worn, pitted or scored, but not seriously weakened Both, Corroding (1.1.14 (a) (ii))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Rear Subframe mounting prescribed area is corroded but not considered excessive Both (5.3.6 (a) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement All, Deteriorating (5.3.4 (a) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Both, Forward, Separating, Considerable! (5.3.4 (a) (i))

Side repeater slightly discoloured Both (4.4.3 (a))

Front Inner Suspension arm pin or bush worn but not resulting in excessive movement Both, Deteriorating (5.3.4 (a) (i))

General Corrosion Underside of Vehicle & suspension Components

Headlamp lens slightly defective Both (4.1.1 (b) (i))

Nearside Front Brake pad(s) wearing thin Appear Low (1.1.13 (a) (ii))

Nearside Front Inner Road wheel slightly distorted Considerable (5.2.2 (c) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Front Play in steering rack inner joint(s) Considerable ()

Offside Rear Combination Lamp Lens Damaged

Offside Rear Tyre has a cut but not deep enough to reach the ply or cords (5.2.3 (d) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened Both, Corroding (1.1.14 (a) (ii))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement All, Deteriorating (5.3.4 (a) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Both, Forward, Separating (5.3.4 (a) (i))

Side repeater slightly discoloured Both (4.4.3 (a))

Front Brake disc worn, but not excessively both fronts (inner faces) (1.1.14 (a) (i))

Front Coil spring corroded both fronts (5.3.1 (b) (i))

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement both sides front bushes (5.3.4 (a) (i))

Items removed from driver's view prior to test ()

Nearside Front Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Nearside Headlamp has a product on the lens but not seriously reducing light output beam image poor (needs attention) (4.1.4 (b))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Nearside Rear Upper Suspension spring mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Headlamp has a product on the lens but not seriously reducing light output beam image poor (needs attention) (4.1.4 (b))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Rear Upper Suspension spring mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Play in steering rack inner joint(s) offside excessive (needs attention) ()

Rear Coil spring corroded both rears (needs attention) (5.3.1 (b) (i))

Rear Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement all bushes deteriorating (5.3.4 (a) (i))

handbrake effort low

offside front tyre getting low on tread (235/60x18)

offside rear light lens damaged

surface corrosion underneath on some components and under body

Coil spring corroded All (5.3.1 (b) (i))

Headlight aims only just met requirements

Nearside Rear Nail in tyre ()

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Rear Light unit damaged

Parking brake efficiency only just met requirements, attention required

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Rear suspension components corroded

Offside Front Outer Drive shaft joint constant velocity boot split or insecure, no longer prevents the ingress of dirt (6.1.7 (g) (ii))

Coil spring corroded All (5.3.1 (b) (i))

Headlight aims only just met requirements

Nearside Rear Nail in tyre ()

Offside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Rear Light unit damaged

Parking brake efficiency only just met requirements, attention required

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Rear suspension components corroded

Nearside Headlamp has a product on the lens but not seriously reducing light output (4.1.4 (b))

Nearside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Headlamp has a product on the lens but not seriously reducing light output (4.1.4 (b))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Rear Suspension arm pin or bush worn but not resulting in excessive movement trailing arm (5.3.4 (a) (i))

Offside Front Inner Track rod end ball joint has slight play (2.1.3 (b) (i))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement trailing arm (5.3.4 (a) (i))

Nearside Front Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Nearside Rear Suspension arm pin or bush worn but not resulting in excessive movement trailing arm bush (5.3.4 (a) (i))

Offside Front Inner Track rod end ball joint has slight play inner steering rod (2.1.3 (b) (i))

Offside Front Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement trailing arm bush (5.3.4 (a) (i))

Registration plate lamp not working Both (1.1.C.1d)

Nearside Front Tyre has a cut in outer sidewall

Nearside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Front Inner steering rod

Offside Front Outer Front constant velocity joint gaiter damaged, but preventing the ingress of dirt (2.5.C.1a)

Offside Front brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

small oil leak

Nearside Side repeater slightly discoloured (1.4.A.2f)

Offside Side repeater slightly discoloured (1.4.A.2f)

Oil leak coming from Angle gear area

Play in steering rack inner joint(s)

Nearside Front Suspension arm rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement (2.4.G.2)

Nearside Front Lower Suspension arm rubber bush bonding deteriorated resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

slight free play in steering rack

brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

front tyres 2.5 mm only

Front brake disc in such a condition that it is seriously weakened (3.5.1i)

slight play in offside steering arm inner balljoint

Nearside Rear Parking brake: parking brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside Rear brake disc excessively pitted (3.5.1h)

Nearside Rear brake disc excessively scored (3.5.1h)

Offside Rear brake disc excessively pitted (3.5.1h)

Offside Rear brake disc excessively scored (3.5.1h)