2005 Suzuki Carry

Nearside Front Tyre worn close to legal limit/worn on edge Slightly worn on inner edge (5.2.3 (e))

Exhaust mounting defective Centre mounting missing but exhaust still secure (6.1.2 (a))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Coil spring corroded Nearside and Offside (5.3.1 (b) (i))

Front Slam panel corroded Nearside and Offside not prescribed area

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Front Subframe mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Nearside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside and offside inner wheel arch corroded and holed but not prescribed area at rear

Offside Front Inner and Outer sill corroded and holed but not prescribed area

Offside Front Tyre worn close to legal limit/worn on edge Worn on outer edge (5.2.3 (e))

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material Nearside and Offside , Also central brake pipe (1.1.11 (c))

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Rear Suspension arm corroded but not seriously weakened Nearside and Offside (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Nearside and Offside Trailing arm (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Brake performance unable to be tested Due to leaking brake pipe (1.2.1 (g))

Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c))

Exhaust has a major leak of exhaust gases Hole in middle box (6.1.2 (a))

Nearside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner wing corroded and holed (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner wing corroded and holed (5.3.6 (a) (i))

Offside Rear Upper Brake pipe excessively corroded (1.1.11 (c))

Nearside Rear Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Offside Front Brake pipe leaking on a hydraulic braking system (1.1.11 (b) (ii)) DANGEROUS

Offside Rear Tyre tread depth below requirements of 1.6mm (5.2.3 (e)) DANGEROUS

Exhaust mounting defective Centre mounting missing but exhaust still secure (6.1.2 (a))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Coil spring corroded Nearside and Offside (5.3.1 (b) (i))

Front Slam panel corroded Nearside and Offside not prescribed area

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Front Subframe mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Nearside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Nearside Front Tyre worn close to legal limit/worn on edge Slightly worn on inner edge (5.2.3 (e))

Nearside and offside inner wheel arch corroded and holed but not prescribed area at rear

Offside Front Inner and Outer sill corroded and holed but not prescribed area

Offside Front Tyre worn close to legal limit/worn on edge Worn on outer edge (5.2.3 (e))

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material Nearside and Offside , Also central brake pipe (1.1.11 (c))

Rear Suspension arm corroded but not seriously weakened Nearside and Offside (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Nearside and Offside Trailing arm (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. Front and Rear slightly imbalanced (1.2.1 (b) (i))

Exhaust has a minor leak of exhaust gases Middle box (6.1.2 (a))

Exhaust mounting defective Centre exhaust mounting detached from exhaust but still secure (6.1.2 (a))

Front Brake pipe corroded, covered in grease or other material Nearside and Offside (1.1.11 (c))

Front Coil spring corroded Nearside and Offside (5.3.1 (b) (i))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Offside front inner and outer sill corroded and holed but not prescribed area

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material Nearside and Offside , Also central brake pipe (1.1.11 (c))

Rear Nearside and Offside inner wheel arch corroded and holed at rear but not prescribed area

Rear Suspension arm corroded but not seriously weakened Nearside and Offside Trailing arm (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Nearside and Offside Trailing arm , Also bushes deteriorated (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Offside Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner and Outer sill corroded and holed front and rear (5.3.6 (a) (i))

Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. Front and Rear slightly imbalanced (1.2.1 (b) (i))

Exhaust has a minor leak of exhaust gases Middle box (6.1.2 (a))

Exhaust mounting defective Centre exhaust mounting detached from exhaust but still secure (6.1.2 (a))

Front Brake pipe corroded, covered in grease or other material Nearside and Offside (1.1.11 (c))

Front Coil spring corroded Nearside and Offside (5.3.1 (b) (i))

Front Sub-frame corroded but not seriously weakened (5.3.3 (b) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material Nearside and Offside , Also central brake pipe (1.1.11 (c))

Rear Nearside and Offside inner wheel arch corroded and holed at rear but not prescribed area

Rear Suspension arm corroded but not seriously weakened Nearside and Offside Trailing arm (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Nearside and Offside Trailing arm , Also bushes deteriorated (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement Nearside and Offside "D" bush (5.3.4 (a) (i))

Front Brake pipe corroded, covered in grease or other material Both sides (1.1.11 (c))

Front Coil spring corroded Nearside and Offside (5.3.1 (b) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Offside Rear Wheel bearing slightly noisy (5.1.3 (b) (i))

Offside outer sill corroded and small hole but not a prescribed area

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material Both sides , Also central brake pipe (1.1.11 (c))

Rear Nearside and Offside Inner wheel arch corroded and holed but not a prescribed area

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Rear Suspension arm corroded but not seriously weakened Nearside and Offside Trailing arms (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Nearside and Offside (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Nearside Front Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))

Nearside Rear Service brake excessively binding (1.2.1 (f))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement Nearside and Offside "D" bush (5.3.4 (a) (i))

Front Brake pipe corroded, covered in grease or other material Both sides (1.1.11 (c))

Front Coil spring corroded Nearside and Offside (5.3.1 (b) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Hand brake has little reserve travel

Offside Rear Wheel bearing slightly noisy (5.1.3 (b) (i))

Offside outer sill corroded and small hole but not a prescribed area

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material Both sides , Also central brake pipe (1.1.11 (c))

Rear Nearside and Offside Inner wheel arch corroded and holed but not a prescribed area

Rear Service brake fluctuating, but not excessively (1.2.1 (e))

Rear Suspension arm corroded but not seriously weakened Nearside and Offside Trailing arms (5.3.3 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Nearside and Offside (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement "D" bushes both sides (5.3.4 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Brake pipe corroded, covered in grease or other material Both sides (1.1.11 (c))

Front Coil spring corroded Both sides (5.3.1 (b) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Hand brake has little reserve travel

Nearside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge Tread depth at 2mm (5.2.3 (e))

Offside Front Service brake binding but not excessively (1.2.1 (f))

Offside Rear Tyre worn close to legal limit/worn on edge Tread depth at 2.3mm (5.2.3 (e))

Offside rear inner wheel arch corroded and holed but not a prescribed area

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material Both sides also central brake pipes (1.1.11 (c))

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Both sides (5.3.4 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Chassis corroded and holed (5.3.6 (a) (i))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement "D" bushes both sides (5.3.4 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Brake pipe corroded, covered in grease or other material Both sides (1.1.11 (c))

Front Coil spring corroded Both sides (5.3.1 (b) (i))

Front Suspension component mounting prescribed area is corroded but not considered excessive Nearside and Offside (5.3.6 (a) (i))

Hand brake has little reserve travel

Nearside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge Tread depth at 2mm (5.2.3 (e))

Offside Front Service brake binding but not excessively (1.2.1 (f))

Offside Rear Tyre worn close to legal limit/worn on edge Tread depth at 2.3mm (5.2.3 (e))

Offside rear inner wheel arch corroded and holed but not a prescribed area

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material Both sides also central brake pipes (1.1.11 (c))

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Both sides (5.3.4 (a) (i))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement "D" Bushes (5.3.4 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Brake pipe corroded, covered in grease or other material Both sides (1.1.11 (c))

Front Coil spring corroded Both sides (5.3.1 (b) (i))

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Front Service brake binding but not excessively (1.2.1 (f))

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Rear Brake pipe corroded, covered in grease or other material Both sides , Also central pipes (1.1.11 (c))

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Both sides (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Both sides (5.3.6 (a) (i))

Offside Front Suspension component mounting prescribed area excessively corroded significantly reducing structural strength Inner wheel arch corroded and holed (5.3.6 (a) (i))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement "D" Bushes (5.3.4 (a) (i))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brake pad(s) wearing thin (1.1.13 (a) (ii))

Front Brake pipe corroded, covered in grease or other material Both sides (1.1.11 (c))

Front Coil spring corroded Both sides (5.3.1 (b) (i))

Nearside Front Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Offside Front Service brake binding but not excessively (1.2.1 (f))

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Rear Brake pipe corroded, covered in grease or other material Both sides , Also central pipes (1.1.11 (c))

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Both sides (5.3.4 (a) (i))

Rear Suspension component mounting prescribed area is corroded but not considered excessive Both sides (5.3.6 (a) (i))

Front Anti-roll bar pin or bush worn but not resulting in excessive movement "D" bushes (5.3.4 (a) (i))

Front Brake pipe corroded, covered in grease or other material Both sides (1.1.11 (c))

Front Coil spring corroded (5.3.1 (b) (i))

Offside Front Service brake binding but not excessively (1.2.1 (f))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Play in steering rack inner joint(s) ()

Rear Brake pipe corroded, covered in grease or other material Both sides (1.1.11 (c))

Rear Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Brake pipe corroded, covered in grease or other material Nearside and Offside front (1.1.11 (c))

Brake pipe corroded, covered in grease or other material Offside and nearside rear (1.1.11 (c))

Front Coil spring corroded (5.3.1 (b) (i))

Offside Rear Suspension component mounting prescribed area is corroded but not considered excessive (5.3.6 (a) (i))

Play in steering rack inner joint(s) ()

Front Coil spring corroded both (5.3.1 (b) (i))

Nearside Front Suspension arm ball joint has slight play (5.3.4 (a) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge 1.9 mm in centre (5.2.3 (e))

Offside Front Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Shock absorbers light misting of oil or has limited damping effect (5.3.2 (b))

Offside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Rear Tyre worn close to legal limit/worn on edge 1.8 mm in outer primary (5.2.3 (e))

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

Front Brake pad(s) wearing thin (3.5.1g)

Front Shock absorber has a light misting of oil both (2.7.3)

Front coil spring corroded both (2.4.C.1b)

Offside Lower inner sill corroded

Play in steering rack inner joint(s) ()

Front coil spring corroded both sides (2.4.C.1b)

Items removed from driver's view prior to test ()

Offside Lower inner sill rusty

Steering system has slight free play detected at steering wheel rack (2.2.A.1b)

Nearside Front coil spring corroded (2.4.C.1b)

Nearside Rear Tyre worn close to the legal limit 2.5mm (4.1.E.1)

Offside Front coil spring corroded (2.4.C.1b)

Offside Rear Tyre worn close to the legal limit 2.3mm (4.1.E.1)

centre exhaust mounting bracket broken on silencer - exhaust still secure

Nearside Front coil spring corroded (2.4.C.1b)

Nearside Rear Tyre worn close to the legal limit 2.5mm (4.1.E.1)

Nearside Registration plate lamp not working (1.1.C.1d)

Nearside Stop lamp not working (1.2.1b)

Offside Front coil spring corroded (2.4.C.1b)

Offside Rear Tyre worn close to the legal limit 2.3mm (4.1.E.1)

Offside Registration plate lamp not working (1.1.C.1d)

centre exhaust mounting bracket broken on silencer - exhaust still secure

Nearside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Offside Rear Trailing arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Play in steering rack inner joint(s)

Rear Brake hose has slight corrosion to ferrules (3.6.B.4e)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

rear exhaust deteriorated

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

Offside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Headlamp aim too high (1.8)

Offside Headlamp aim too high (1.8)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Rear wheel bearing has slight play (2.6.2)

Offside Front Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Rear wheel bearing has slight play (2.6.2)

Play in steering rack inner joint(s)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

rear exhaust deteriorated

Rear Exhaust system not adequately supported (7.1.1)

Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Rear wheel bearing has slight play (2.6.2)

Offside Front Anti-roll bar linkage has slight play in a pin/bush (2.4.G.2)

Offside Rear wheel bearing has slight play (2.6.2)

Play in steering rack inner joint(s)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

rear exhaust deteriorated

Nearside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Nearside Rear wheel bearing has slight play (2.6.2)

Offside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Offside Rear wheel bearing has slight play (2.6.2)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

nearside sill damaged at front

Offside Front Lower Suspension arm has excessive play in a ball joint (2.4.G.2)

Nearside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Nearside Rear wheel bearing has slight play (2.6.2)

Offside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Offside Rear wheel bearing has slight play (2.6.2)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

nearside sill damaged at front

Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Offside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Rear Brake hose has slight corrosion to ferrules (3.6.B.4e)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

rear upper shock absorber mounts have slight corrosion

Offside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Parking brake lever has no reserve travel (3.1.6b)

Front Brake hose has slight corrosion to ferrules (3.6.B.4e)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Offside Rear Lower Shock absorber has a slightly worn bush (2.7.4)

Rear Brake hose has slight corrosion to ferrules (3.6.B.4e)

Rear Exhaust has part of the system slightly deteriorated (7.1.1a)

rear upper shock absorber mounts have slight corrosion

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Outer Front Brake pad(s) wearing thin (3.5.1g)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Rear wheel bearing has slight play (2.6.2)

Steering system has slight free play detected at steering wheel (2.2.A.1b)

Nearside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Offside Front Tyre tread depth below requirements of 1.6mm (4.1.E.1)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Outer Front Brake pad(s) wearing thin (3.5.1g)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Rear wheel bearing has slight play (2.6.2)

Service brake: service brake efficiency only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.7)

Steering system has slight free play detected at steering wheel (2.2.A.1b)