2004 Volvo XC90

Handbrake just met minimum requirements at 16% efficiency.

Headlamp lens slightly defective Offside and nearside lenses oxidised. Beam pattern slightly poor (4.1.1 (b) (i))

Nearside Front Tyre worn close to legal limit/worn on edge Heavily worn on outer edge. (5.2.3 (e))

Nearside Rear Coil spring appears to be incorrectly located on top coil/mounting

Nearside Rear reflector defective or damaged by up to 50% of the reflecting surface Cracked (4.8.1 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b))

Offside Headlamp has a product on the lens but not seriously reducing light output Condensation inside light unit (4.1.4 (b))

Offside Side repeater slightly discoloured (4.4.3 (a))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Offside and nearside trailing arm, front bushes heavily deteriorated/de-bonding. (5.3.4 (a) (i))

Steering rack has slight free play detected at steering wheel Play/lift in offside of steering rack, inside rack gaiter. ADVISE INVESTIGATION/REPAIR (2.3 (a) (i))

Suspension arm pin or bush worn but not resulting in excessive movement All rear bushes deteriorated/slight play (5.3.4 (a) (i))

Suspension component mounting prescribed area is corroded but not considered excessive General age related corrosion to chassis rails, floor, inner wheel arches/turret tops and suspension components. (5.3.6 (a) (i))

Nearside Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Offside Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Handbrake just met minimum requirements at 16% efficiency.

Headlamp lens slightly defective Offside and nearside lenses oxidised. Beam pattern slightly poor (4.1.1 (b) (i))

Nearside Front Tyre worn close to legal limit/worn on edge Heavily worn on outer edge. (5.2.3 (e))

Nearside Rear Coil spring appears to be incorrectly located on top coil/mounting

Nearside Rear reflector defective or damaged by up to 50% of the reflecting surface Cracked (4.8.1 (a) (i))

Offside Front Seat belt webbing slightly damaged or frayed (7.1.2 (b))

Offside Headlamp has a product on the lens but not seriously reducing light output Condensation inside light unit (4.1.4 (b))

Offside Side repeater slightly discoloured (4.4.3 (a))

Rear Suspension arm pin or bush worn but not resulting in excessive movement Offside and nearside trailing arm, front bushes heavily deteriorated/de-bonding. (5.3.4 (a) (i))

Steering rack has slight free play detected at steering wheel Play/lift in offside of steering rack, inside rack gaiter. ADVISE INVESTIGATION/REPAIR (2.3 (a) (i))

Suspension arm pin or bush worn but not resulting in excessive movement All rear bushes deteriorated/slight play (5.3.4 (a) (i))

Suspension component mounting prescribed area is corroded but not considered excessive General age related corrosion to chassis rails, floor, inner wheel arches/turret tops and suspension components. (5.3.6 (a) (i))

Fluid leak, but not excessive Hydraulic fluid leak at front of vehicle, cannot determine if power steering or auto transmission fluid leak? (Undertray fitted fitted making full assessment difficult. (8.4.1 (a) (i))

Nearside Rear Lower Suspension arm pin or bush worn but not resulting in excessive movement Trailing arm bushes heavily worn/deteriorated (5.3.4 (a) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge Close to legal limit/Heavily worn on outer edge (5.2.3 (e))

Nearside Rear Wheel bearing slightly noisy (5.1.3 (b) (i))

Offside Rear Lower Suspension arm pin or bush worn but not resulting in excessive movement Trailing arm bushes heavily worn/deteriorated (5.3.4 (a) (i))

Offside Rear Tyre worn close to legal limit/worn on edge Close to legal limit (5.2.3 (e))

Offside Track rod end ball joint has slight play (2.1.3 (b) (i))

Oil leak, but not excessive Engine (8.4.1 (a) (i))

Suspension arm pin or bush worn but not resulting in excessive movement All rear suspension bushes worn/deteriorated (5.3.4 (a) (i))

Suspension component mounting prescribed area is corroded but not considered excessive General age related corrosion to underbody and suspension components. (5.3.6 (a) (i))

Nearside Front Suspension arm ball joint excessively worn (5.3.4 (a) (i))

Nearside Headlamp aim projected beam image is obviously incorrect Suspect bulb not fitted correctly (4.1.2 (c))

Nearside Headlamp lens seriously defective Lens oxidised (4.1.1 (b) (ii))

Offside Headlamp aim projected beam image is obviously incorrect (4.1.2 (c))

Offside Headlamp lens seriously defective Lens oxidised (4.1.1 (b) (ii))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Fluid leak, but not excessive Hydraulic fluid leak at front of vehicle, cannot determine if power steering or auto transmission fluid leak? (Undertray fitted fitted making full assessment difficult. (8.4.1 (a) (i))

Nearside Rear Lower Suspension arm pin or bush worn but not resulting in excessive movement Trailing arm bushes heavily worn/deteriorated (5.3.4 (a) (i))

Nearside Rear Tyre worn close to legal limit/worn on edge Close to legal limit/Heavily worn on outer edge (5.2.3 (e))

Nearside Rear Wheel bearing slightly noisy (5.1.3 (b) (i))

Offside Rear Lower Suspension arm pin or bush worn but not resulting in excessive movement Trailing arm bushes heavily worn/deteriorated (5.3.4 (a) (i))

Offside Rear Tyre worn close to legal limit/worn on edge Close to legal limit (5.2.3 (e))

Offside Track rod end ball joint has slight play (2.1.3 (b) (i))

Oil leak, but not excessive Engine (8.4.1 (a) (i))

Power steering fluid level below minimum (2.1.5 (b) (i))

Suspension arm pin or bush worn but not resulting in excessive movement All rear suspension bushes worn/deteriorated (5.3.4 (a) (i))

Suspension component mounting prescribed area is corroded but not considered excessive General age related corrosion to underbody and suspension components. (5.3.6 (a) (i))

Nearside Rear Wheel bearing slightly noisy (5.1.3 (b) (i))

Nearside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Lower Suspension arm ball joint dust cover severely deteriorated (5.3.4 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement both rear suspension lower arm front bushes (5.3.4 (a) (i))

Rear exhaust heat shield loose

Steering rack has slight free play detected at steering wheel (2.3 (a) (i))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement wishbone bushes perished (5.3.4 (a) (i))

Offside Front Inner Play in steering rack inner joint(s) ()

Offside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Offside Rear Shock absorbers has light misting of oil (5.3.2 (b))

Rear Shock absorbers has a slightly worn bush all rear bushes perishing (5.3.2 (c))

Front Headlamp has a product on the lens but not seriously reducing light output both (4.1.4 (b))

Front Inner Brake pad(s) wearing thin (1.1.13 (a) (ii))

Offside Front Play in steering rack inner joint(s) ()

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing cracking and cuts (5.2.3 (d) (ii))

Rear Suspension arm pin or bush worn but not resulting in excessive movement all bushes (5.3.4 (a) (i))

Front Windscreen washer not working (3.5 (a))

Offside Front Tyre has ply or cords exposed (5.2.3 (d) (ii)) DANGEROUS

Front Headlamp has a product on the lens but not seriously reducing light output both (4.1.4 (b))

Front Inner Brake pad(s) wearing thin (1.1.13 (a) (ii))

Offside Front Play in steering rack inner joint(s) ()

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Tyre slightly damaged/cracking or perishing cracking and cuts (5.2.3 (d) (ii))

Rear Suspension arm pin or bush worn but not resulting in excessive movement all bushes (5.3.4 (a) (i))

Front Suspension arm pin or bush worn but not resulting in excessive movement o/s wishbone (5.3.4 (a) (i))

Headlamp lens slightly defective n/s o/s (4.1.1 (b) (i))

Nearside Front Tyre worn close to legal limit/worn on edge 235/60/18 (5.2.3 (e))

Offside Play in steering rack inner joint(s) ()

Headlamp lens seriously defective n/s o/s (4.1.1 (b) (ii))

Nearside Headlamp not working on dipped beam (4.1.1 (a) (ii))

Nearside Stop lamp(s) not working (4.3.1 (a) (ii))

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Front Suspension arm pin or bush worn but not resulting in excessive movement o/s wishbone (5.3.4 (a) (i))

Nearside Front Tyre worn close to legal limit/worn on edge 235/60/18 (5.2.3 (e))

Offside Play in steering rack inner joint(s) ()

Nearside Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Rear Suspension arm pin or bush worn but not resulting in excessive movement front bush at chassis support (5.3.4 (a) (i))

Nearside Front Headlamp not working on dipped beam (4.1.1 (a) (ii))

Nearside Front Lower Anti-roll bar linkage ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Position lamp not working (4.2.1 (a))

Offside Front Position lamp not working (4.2.1 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Registration plate lamp inoperative in the case of a single lamp or all lamps both lamps (4.7.1 (b) (ii))

Nearside Rear Brake pad(s) wearing thin (1.1.13 (a) (ii))

Offside front tyre worn inner and outer edge. On legal limit.

Offside steering rack inner joint has slight play

Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Front Brake pad(s) less than 1.5 mm thick (3.5.1g)

Parking brake: efficiency below requirements (3.7.C.1b)

Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Both rear trailing arm bushes started to crack.

Exhaust bracket snapped

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Slight wheel bind offside rear.

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Nearside Headlamp aim too high (1.8)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Headlamp aim too low (1.8)

Offside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Rear Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)