2007 Citroen Relay

N/S/F AND N/S/R OUTER SILLS ALSO O/S/F AND O/S/R INNER SILL COVERED IN UNDERSEAL UNABLE TO CHECK 100% OF REPAIR. AT TIME OF TEST LOOKED OK

Nearside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Nearside Outer Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Offside Inner Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Offside Outer Vehicle structure or chassis has excessive corrosion, seriously affecting its strength within 30cm of a body mounting sill (6.2.2 (d) (i))

Nearside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Front Outer Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced End of sill. (marked in yellow) (6.1.1 (c) (i))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Brake pad(s) less than 1.5 mm thick (1.1.13 (a) (ii)) DANGEROUS

Nearside Rear Handbrake force low.

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement ns/os (5.3.4 (a) (i))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside door step repaired with plastic,

Rear Leaf spring has slight wear in an anchor pin and/or bush ns/os (5.3.4 (a) (i))

offside sill/inner sill welded/heavily undersealed.

Nearside Front Service brake excessively binding (1.2.1 (f))

Offside Rear fog lamp not working (4.5.1 (a) (ii))

Rear Brakes imbalanced across an axle Axle 2 (1.2.1 (b) (i))

Registration plate lamp inoperative in the case of a single lamp or all lamps (4.7.1 (b) (ii))

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Front Lower Suspension arm pin or bush worn but not resulting in excessive movement ns/os (5.3.4 (a) (i))

Offside Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Offside door step repaired with plastic,

Rear Leaf spring has slight wear in an anchor pin and/or bush ns/os (5.3.4 (a) (i))

offside sill/inner sill welded/heavily undersealed.

Nearside Front Shock absorbers has light misting of oil (5.3.2 (b))

Rear Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (1.2.1 (b) (i))

exhaust slightly deteriorated

nearside front outer sill holed, not within prescribed area

offside rear tyre slightly perished

underside and welding repairs covered with underseal

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Nearside Front Shock absorbers has light misting of oil (5.3.2 (b))

exhaust slightly deteriorated

nearside front outer sill holed, not within prescribed area

offside rear tyre slightly perished

underside and welding repairs covered with underseal

Nearside Front Lower Suspension component ball joint excessively worn (5.3.4 (a) (i))

Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Nearside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength inner sill (5.3.6 (a) (i))

Offside Rear Suspension component mounting prescribed area excessively corroded significantly reducing structural strength outer sill (5.3.6 (a) (i))

Headlamp lens slightly defective both front headlamp lens (4.1.1 (b) (i))

Nearside Front Inner Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Nearside Front Shock absorbers has light misting of oil (5.3.2 (b))

Nearside Front outer sill heavily corroded (hole) not in prescribed area

Offside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Suspension arm pin or bush worn but not resulting in excessive movement both front lower arm rear bushes (5.3.4 (a) (i))

Tyre worn close to legal limit/worn on edge both front tyres wearing slightly outer edge (5.2.3 (e))

both rear bump stop mounting areas heavily corroded

exhaust outer skin slightly deteriorated

Nearside Rear Tyre worn close to legal limit/worn on edge tyre worn on edges (5.2.3 (e))

Offside Rear Tyre worn close to legal limit/worn on edge rear tyres worn on edges (5.2.3 (e))

Rear rear leaf springs rusty

under body of van has light corrosion in afew places

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Inner Brake pad(s) wearing thin (1.1.13 (a) (ii))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement Rear lower arm bush (5.3.4 (a) (i))

Nearside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Integral body structure is corroded but structural rigidity is not significantly reduced Nearside outer sill corroded (6.1.1 (c) (i))

Nearside Rear Tyre slightly damaged/cracking or perishing (5.2.3 (d) (ii))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement Rear lower arm bush (5.3.4 (a) (i))

Offside Integral body structure is corroded but structural rigidity is not significantly reduced Offside outer sill corroded (6.1.1 (c) (i))

Offside Rear Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Integral body structure is corroded but structural rigidity is not significantly reduced o/s & n/s outer sill's (6.1.1 (c) (i))

Nearside Front Inner Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement Lower arm rear bush (5.3.4 (a) (i))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement Lower arm rear bush (5.3.4 (a) (i))

Offside Rear Tyre worn close to legal limit/worn on edge 3mm (5.2.3 (e))

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Nearside Front Lower Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Nearside Front Lower Windscreen has damage to an area less than a 10mm circle within zone 'A' (8.3.1a)

Offside Front position lamp(s) insecure (1.1.A.3a)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Exhaust has a major leak of exhaust gases weld on cat broken (7.1.2)

Exhaust system not adequately supported center/back box corroded (7.1.1)

Nearside Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Front Headlamp aim too low (1.8)

Offside Front Suspension arm rubber bush deteriorated resulting in excessive movement rear bush (2.4.G.2)

Offside Front Windscreen wiper does not clear the windscreen effectively (8.2.2)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement rear bush (2.4.G.2)

Offside Front Tyre worn close to the legal limit 215/70/15c (4.1.E.1)

Exhaust rubbers split/worn

Nearside Front Mechanical brake component has restricted free movement (3.5.1k)

Nearside Registration plate lamp not working (1.1.C.1d)

Nearside Windscreen washer provides insufficient washer liquid (8.2.3)

Offside Registration plate lamp not working (1.1.C.1d)

Windscreen wiper not operating automatically when switched on (8.2.1b)

Exhaust rubbers split/worn

centre exhaust jacket outer skin corroding

no smoke detected

vehicle over loaded

NOTE MAIN CENTER SILENCER CORRODED

Nearside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Offside Rear brake disc worn, pitted or scored, but not seriously weakened (3.5.1i)

Exhaust has part of the system slightly deteriorated (7.1.1a)

rear discs pitted on edges

Nearside rear brake binding (3.7.B.1)

Registration plate lamp not working (1.1.C.1d)

Exhaust has part of the system slightly deteriorated (7.1.1a)

rear discs pitted on edges