2004 Volvo S40

Front Brake pipe corroded, covered in grease or other material and rear various places (1.1.11 (c))

Front Suspension arm pin or bush worn but not resulting in excessive movement both sides (5.3.4 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Rear Exhaust mounting defective (6.1.2 (a))

Rear Suspension arm pin or bush worn but not resulting in excessive movement both sides trailing arm bushes (5.3.4 (a) (i))

Brake lever has insufficient reserve travel (1.1.2 (a))

Emissions unable to be completed exhaust leak and oil leak (8.2.1.2 (d))

Front Exhaust has a major leak of exhaust gases manifold (6.1.2 (a))

Nearside Headlamp aim too high (4.1.2 (a))

Offside Headlamp aim too high (4.1.2 (a))

Oil leaking excessively from engine (8.4.1 (a) (i))

Front Brake pipe corroded, covered in grease or other material and rear various places (1.1.11 (c))

Front Suspension arm pin or bush worn but not resulting in excessive movement both sides (5.3.4 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Rear Exhaust mounting defective (6.1.2 (a))

Rear Suspension arm pin or bush worn but not resulting in excessive movement both sides trailing arm bushes (5.3.4 (a) (i))

Brake lever has abnormal movement of levers indicating excessive wear or maladjustment (1.1.15 (f))

Exhaust Lambda reading after 2nd fast idle outside specified limits (8.2.1.2 (c))

Exhaust carbon monoxide content after 2nd fast idle exceeds manufacturer's specified limits (8.2.1.2 (a))

Exhaust emits excessive dense blue smoke during acceleration (8.2.1.2 (g))

Exhaust hydrocarbon content after 2nd fast idle exceeds default limits (8.2.1.2 (b))

Nearside Headlamp light intensity severely reduced (4.1.4 (a))

Offside Headlamp aim too low (4.1.2 (a))

Offside Parking brake inoperative on one side (1.4.1 (a))

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Front Exhaust mounting defective (6.1.2 (a))

Offside Rear Direction indicator slightly discoloured (4.4.3 (a))

Exhaust has a minor leak of exhaust gases (6.1.2 (a))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Rear Inner Tyre worn close to legal limit/worn on edge (5.2.3 (e))

Offside Front Shock absorbers has a serious fluid leak (5.3.2 (b))

Front Anti-roll bar damaged but not seriously weakened both side (5.3.3 (b) (i))

all brake pipes and suspension heavily undersealed

Nearside Front Lower Suspension arm has slight play in a ball joint (2.4.G.2)

Nearside Headlamp aim too low (1.8)

Offside Front Suspension arm has excessive play in a ball joint (2.4.G.2)

Offside Front wheel bearing rough when rotated (2.5.A.2)

Rear Brake pad(s) less than 1.5 mm thick (3.5.1g)

Front Brake pad(s) wearing thin (3.5.1g)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

o/s/f tyre worn on inner edge

Nearside Front Anti-roll bar linkage ball joint dust cover damaged, but preventing the ingress of dirt (2.4.G.2)

nearside front anti roll bar link dust cover split

nearside front suspension arm rear bush starting to split

slight oil leak from gearbox

Rear Brake pad(s) wearing thin (3.5.1g)

front wipers are smeering the screen slightly

Offside Rear Direction indicator slightly discoloured (1.4.A.2f)

Tyre worn close to the legal limit (4.1.E.1)