2004 Volvo S60

Nearside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut mounting (5.3.6 (a) (i))

Offside Front Upper Suspension component mounting prescribed area excessively corroded significantly reducing structural strength strut mounting (5.3.6 (a) (i))

All coil springs corroded

Front and rear shock absorbers corroded

Nearside Rear Service brake binding but not excessively (1.2.1 (f))

Offside Front Brake hose has slight corrosion to ferrule on limit (1.1.12 (f) (i))

Offside Front Outer Drive shaft joint constant velocity boot severely deteriorated (6.1.7 (g) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Offside Front tyre slight rubbing on plastic on lock

Offside Rear Brake hose has slight corrosion to ferrule (1.1.12 (f) (i))

Offside Rear Tyre slightly damaged/cracking or perishing cracks (5.2.3 (d) (ii))

Rear suspension corroded

Front Coil spring corroded X2 AND SOFT (5.3.1 (b) (i))

Front Direction indicator slightly discoloured BOTH\WHITE (4.4.3 (a))

Nearside Front Non obligatory mirror damaged ()

Offside Front POOR\IMAGE\CONDENSATION

Offside Rear Suspension arm pin or bush worn but not resulting in excessive movement X2 (5.3.4 (a) (i))

Parking brake lever defective but can be satisfactorily operated TRAVEL##POOR## (1.1.6 (d))

Rear Anti-roll bar linkage ball joint has slight play BOTH\SIDES##POOR## (5.3.4 (a) (i))

Rear Anti-roll bar pin or bush worn but not resulting in excessive movement DOMES (5.3.4 (a) (i))

Rear Coil spring corroded X2 (5.3.1 (b) (i))

Rear Suspension arm pin or bush worn but not resulting in excessive movement TRACK\ARMS\PITTED (5.3.4 (a) (i))

Shock absorbers has slight external damage to the casing ALL 4 CORRODED (5.3.2 (b))

Nearside Front Lower Suspension arm pin or bush excessively worn both bushes (5.3.4 (a) (i))

Nearside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Nearside Front Wheel bearing has excessive play (5.1.3 (a) (i))

Offside Front Integral body structure corroded to the extent that the rigidity of the assembly is significantly reduced within 30cm of strut top mount under bonnet below coolant tank (6.1.1 (c) (i))

Rear Service brake excessively fluctuating (1.2.1 (e))

Front Coil spring corroded both sides and shockers (5.3.1 (b) (i))

Front Direction indicator slightly discoloured both sides (4.4.3 (a))

Nearside Brake pipe corroded, covered in grease or other material front to rear (1.1.11 (c))

Nearside Obligatory mirror slightly damaged missing (3.3 (b) (i))

Offside Front Headlamp has a product on the lens but not seriously reducing light output condensation on inside of glass (4.1.4 (b))

Offside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement both bushes (5.3.4 (a) (i))

Rear all suspension corroded springs , shockers ,arms antirollbar and links

Rear handbrake effort only just met excess travel

ENG\OIL\MIN

Front Suspension arm pin or bush worn but not resulting in excessive movement BUSHS BOTH SIDES (5.3.4 (a) (i))

Nearside Front Track rod end ball joint has slight play (2.1.3 (b) (i))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Rear Inner BELT\SEAT\TRAPPED

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement front bush (5.3.4 (a) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Headlamp lens slightly defective water in headlamp affecting beam slightly (4.1.1 (b) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement both wishbone bushes (5.3.4 (a) (i))

Offside Rear Parking brake inoperative on one side (1.4.1 (a))

Parking brake efficiency below requirements (1.4.2 (a) (i))

Rear Brakes imbalanced across an axle 32% Imbalance (1.2.1 (b) (i))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement front bush (5.3.4 (a) (i))

Nearside Rear Brake pipe corroded, covered in grease or other material (1.1.11 (c))

Offside Front Headlamp lens slightly defective water in headlamp affecting beam slightly (4.1.1 (b) (i))

Offside Front Suspension arm pin or bush worn but not resulting in excessive movement both wishbone bushes (5.3.4 (a) (i))

Offside Registration plate lamp inoperative in the case of multiple lamps or light sources (4.7.1 (b) (i))

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement WISHBUSH (5.3.4 (a) (i))

Anti-lock braking system warning lamp indicates an ABS fault MIL (1.6 (b))

Offside Front Upper Macpherson strut mounting corroded and seriously weakened (5.3.3 (b) (i))

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Nearside Front Lower Suspension arm pin or bush worn but not resulting in excessive movement WISHBUSH (5.3.4 (a) (i))

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Rear Inner Tyre slightly damaged/cracking or perishing WALL SPLITS (5.2.3 (d) (ii))

Rear Anti-roll bar linkage ball joint has slight play AND BUSHS ALL (5.3.4 (a) (i))

Nearside Rear Parking brake inoperative on one side NIL (1.4.1 (a))

Offside Front Track rod end ball joint has excessive play (2.1.3 (b) (i))

Offside Rear Parking brake inoperative on one side DOWN (1.4.1 (a))

Nearside Rear Brake pad(s) less than 1.5 mm thick AND GRAB (1.1.13 (a) (ii)) DANGEROUS

Parking brake efficiency less than 50% of the required value (1.4.2 (a) (ii)) DANGEROUS

Nearside Front Suspension arm pin or bush worn but not resulting in excessive movement (5.3.4 (a) (i))

Nearside Front Wheel bearing has slight play (5.1.3 (a) (i))

Nearside Rear Inner Tyre slightly damaged/cracking or perishing WALL SPLITS (5.2.3 (d) (ii))

Rear Anti-roll bar linkage ball joint has slight play AND BUSHS ALL (5.3.4 (a) (i))

Rear Brake disc worn, pitted or scored, but not seriously weakened (1.1.14 (a) (ii))

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. (3.7.B.5b)

Front Play in steering rack inner joint(s) ()

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement FRONT (2.4.G.2)

Nearside Front wheel bearing has slight play (2.5.A.3c)

Nearside Outer Front constant velocity joint gaiter deteriorated, but preventing the ingress of dirt (2.5.C.1a)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' CHIP (8.3.1d)

Front Brakes imbalanced requirements only just met. It would appear that the braking system requires adjustment or repair. POOR (3.7.B.5b)

Front RACK JOINTS PLAY

Nearside Front Lower Suspension arm rubber bush deteriorated but not resulting in excessive movement FRONT AS MARKED (2.4.G.2)

UNDERTRAYS AND ENG\COVERS

Windscreen has damage to an area less than a 40mm circle outside zone 'A' CHIP (8.3.1d)

Play in steering rack inner joint(s)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Offside Windscreen wiper does not clear the windscreen effectively (8.2.2)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Windscreen has damage to an area less than a 40mm circle outside zone 'A' (8.3.1d)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Front Tyre worn close to the legal limit (4.1.E.1)

Offside Rear Tyre worn close to the legal limit (4.1.E.1)

Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Front Tyre worn close to the legal limit (4.1.E.1)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

nearside track rod ball joint dry and creaking

rear brake discs corroding

Offside Front brake disc excessively pitted (3.5.1h)

Offside Front front brake juddering severely (3.7.A.2b)

Nearside Front Suspension arm rubber bush deteriorated but not resulting in excessive movement (2.4.G.2)

Power steering pipe(s) or hose(s) has slight seepage (2.3.3b)

nearside track rod ball joint dry and creaking

possible fuel leak @ number 3 injector

rear brake discs corroding

wiper blades worn